|
|
PDF HT-0095 Data sheet ( Hoja de datos )
| Número de pieza | HT-0095 | |
| Descripción | Mini PV Receptacles 22-32 AWG Crimping Hand Tool | |
| Fabricantes | FCI connector | |
| Logotipo |  |
|
Hay una vista previa y un enlace de descarga de HT-0095 (archivo pdf) en la parte inferior de esta página. Total 18 Páginas | ||
|
No Preview Available !
www.DataSheet4U.com
ELECTRONICS
HT-0095
Mini PV Receptacles 22-32 AWG Crimping Hand Tool
Tool P/N HT-0095
FCI MANUAL P/N 415988-001
FCI Electronics
Issued: Date (03/12/99)
Rev. 05/07/01 ECR V10337
K\DCU\Manuals
PDM: Rev:B
Manual Part No. 415988-001
Page 1 of 18
Revision B
STATUS: Released Printed: Dec 19, 2002
1 page  
www.DataSheet4U.com
Principles of Operation
ELECTRONICS
The lever attaches to the lower tooling and provides the mechanical advantage to generate the
necessary crimping pressure. As the lever is closed, a ratchet mechanism engages to prevent the
lever from opening until the crimping cycle is complete. When the lever is pulled closed, the lower
tooling and terminal are pushed up against the upper tooling. The crimp is formed between the
wire and insulation barrel anvils and the wire and insulation crimpers. Once closed, the ratchet
releases and allows a spring to pull the lever open.
Specifications
(See TA-75, TA-146)
When crimping the Mini PV™ to wires, the following parameters must be met.
Wire Length Requirements:
• Minimum ……………………………………..19.05 mm (0.75 in.)
• Maximum …………………………………….As Required
Insulation Diameters of Wires:
• "A" Side (28-32 AWG) ………………………0.71-1.37 mm (0.028-0.054 in.) Dia.
• "B" Side (22-26 AWG) ………………………0.91-1.52 mm (0.036-0.060 in.) Dia.
Strip Length of Insulation:
• Discrete and Latch
Housing Applications ……………………….3.81-4.31 mm (0. 150- 0.170 in.)
• Rod Housing
Applications ………………………………….3.30-3.81 mm (0. 130-0.150 in.)
Wire Barrel Crimp Height:
(For All Applications)
• Single Wire 22-26 AWG or
Two Wires 26-28 AWG ……………………..0.81-0.86 mm (0.032-0.034 in.)
• Single Wire 28-32 AWG or
Two Wires 30-32 AWG ……………………..0.66-0.71 mm (0.026-0.028 in.)
Insulation Barrel Crimp Height:
• Discrete Application …………………………2.84 mm (0. 112 in.) Max.
• Latch and Rod Housing
Applications ………………………………….1.75 mm (0.069 in.) Max.
Mini PV™ Receptacles:
• Loose Piece ………………………………….22-32 AWG
NOTE: Loose piece terminals have different part numbers than reeled terminals.
FCI Electronics
Issued: Date (03/12/99)
Rev. 05/07/01 ECR V10337
K\DCU\Manuals
PDM: Rev:B
Manual Part No. 415988-001
Page 5 of 18
Revision B
STATUS: Released Printed: Dec 19, 2002
5 Page 
www.DataSheet4U.com
ELECTRONICS
Anvil Installation
NOTE: When replacing the anvils, be sure that the part numbers for the new anvils are the same
as those being replaced.
1. Insert the 3/32-inch Allen wrench through the access hole in the adjustable tool holder and into
the socket-head setscrew (see Figure 9). Then turn the setscrew 1/4-turn counterclockwise to
unlock the adjusting collar.
Figure 9
2. Insert the turned-down end of the 3/32-inch Allen wrench or a pin, approximately 1/16-inch in
diameter, into one of the holes in the adjusting collar (see Figure 10). Then rotate the collar
about 1/2-turn counterclockwise.
Figure 10
3. Reinstall the anvil holder onto the hand and tighten the attaching cap screw.
CAUTION
To prevent the anvils from being damaged during alignment, place a piece of paper,
plastic bag material, or cellophane over the anvils.
FCI Electronics
Issued: Date (03/12/99)
Rev. 05/07/01 ECR V10337
K\DCU\Manuals
PDM: Rev:B
Manual Part No. 415988-001
Page 11 of 18
Revision B
STATUS: Released Printed: Dec 19, 2002
11 Page | ||
| Páginas | Total 18 Páginas | |
| PDF Descargar | [ Datasheet HT-0095.PDF ] | |
Hoja de datos destacado
| Número de pieza | Descripción | Fabricantes |
| HT-0095 | Mini PV Receptacles 22-32 AWG Crimping Hand Tool | FCI connector |
| Número de pieza | Descripción | Fabricantes |
| SLA6805M | High Voltage 3 phase Motor Driver IC. |
 Sanken |
| SDC1742 | 12- and 14-Bit Hybrid Synchro / Resolver-to-Digital Converters. |
 Analog Devices |
|
DataSheet.es es una pagina web que funciona como un repositorio de manuales o hoja de datos de muchos de los productos más populares, |
| DataSheet.es | 2020 | Privacy Policy | Contacto | Buscar |