|
|
Número de pieza | IR2166 | |
Descripción | PFC & BALLAST CONTROL IC | |
Fabricantes | International Rectifier | |
Logotipo | ||
Hay una vista previa y un enlace de descarga de IR2166 (archivo pdf) en la parte inferior de esta página. Total 29 Páginas | ||
No Preview Available ! Data Sheet No. PD60198-C
IR2166(S)
PFC & BALLAST CONTROL IC
Features
• PFC, Ballast control and half-bridge driver in one IC
• Critical conduction mode boost type PFC
• No PFC current sense resistor required
• Programmable preheat frequency
• Programmable preheat time
• Programmable run frequency
• Programmable over-current protection
• Programmable end-of-life protection
• Programmable dead time
• Internal ignition ramp
• Internal fault counter
• DC bus under-voltage reset
• Shutdown pin with hysteresis
• Internal 15.6V zener clamp diode on Vcc
• Micropower startup (150µA)
• Latch immunity and ESD protection
Description
The IR2166 is a fully integrated, fully protected 600V ballast control IC designed to
drive all types of fluorescent lamps. PFC circuitry operates in critical conduction mode
and provides for high PF, low THD and DC Bus regulation. The IR2166 features in-
clude programmable preheat and run frequencies, programmable preheat time, pro-
grammable dead-time, programmable over-current protection, and programmable end-
of-life protection. Comprehensive protection features such as protection from failure of
a lamp to strike, filament failures, end-of-life protection, DC bus undervoltage reset as
well as an automatic restart function, have been included in the design. The IR2166 is
available in both 16-lead PDIP and 16-lead (narrow body) SOIC packages.
Packages
16-Lead SOIC
(narrow body)
IR2166 Application Diagram
16-Lead PDIP
+ Rectified AC Line
D BUS
R BUS
R SUPPLY
C VDC
C BUS +
R VDC
C PH
VBUS
1
CPH
2
RT RT
3
DZCOMP
RPH
4
CT
RPH
CT
5
CCOMP
COMP
76
R1 ZX
7
PFC
M3 8
R GPFC
HO
16
VS
15
VB
14
VCC
13
COM
12
LO
11
CS
10
SD/EOL
9
CVCC1
R GHS
C BOOT
D BOOT
CVCC2
R GLS
R2
D1
M1
CBLOCK LRES
D CP1
C SNUB
R5
R3
M2
R6
D CP2
R7
R4
RCS
C SD1
CCS C SD2
D2 D3
C EOL R 8
CRES
- Rectified AC Line
*Please note that this data sheet contains advanced information that could change before the product is released to production.
www.irf.com
1
1 page IR2166
Electrical Characteristics cont.
VCC = VBS = VBIAS = 14V +/- 0.25V, VBUS = Open, RT = 39.0kΩ, RPH = 100kΩ, CT = 470 pF, VCPH = 0.0V, VSD = 0.0V,
VCOMP = 0.0V VCS = 0.0V, CLO = CHO = 1000pF, TA = 25oC unless otherwise specified.
Symbol Definition
Min. Typ. Max. Units Test Conditions
RT Characteristics
IRTLK Open circuit RT pin leakage current
VRTFLT Fault-mode RT pin voltage
— 0.1 — µA CT = 10V
—0
— mV SD > 5.0V or CS >1.3V
Protection Circuitry Characteristics
VSDTH+ Rising shutdown pin reset threshold voltage
VSDHYS Shutdown pin 5.0V threshold hysteresis
VSDEOL+ Rising shutdown pin end-of-life threshold volt.
VSDEOL- Falling shutdown pin end-of-life threshold volt.
VCSTH+ Over-current sense threshold voltage
#FAULT- Number of sequential over-current fault
cycles before IC shuts down
VBUSUV- The VBUS threshold below which the IC
shuts down
VCPH CPH pin end-of-life enable threshold
4.7
100
2.4
0.7
1.0
25
2.6
10.3
5.2 5.7
150 350
3.0 3.6
1.0 1.6
1.2 1.3
75 90
3.0 3.3
12 13.2
Gate Driver Output Characteristics (HO, LO and PFC pins)
VOL
VOH
tr
tf
I0+
I0-
Low-level output voltage
High-level output voltage
Turn-on rise time
Turn-off fall time
HO, LO, PFC source current
HO, LO, PFC sink current
—0
—0
100
100
— 110 210
— 55 160
— 300
—
— 400
—
V
mV
V
Cycles
VCPH>12V
VCPH>7.5V
VCPH>7.5V, CYCLES
CS > 1.3V
V
mV
nsec
Io = 0
VBIAS - Vo, Io = 0
CHO = CLO = CPFC
= 1nF
mA
www.irf.com
5
5 Page IR2166
14
12 UVLO+
10 UVLO-
8
6
4
2
0
-25
0
25 50 75 100 125
Temperature (°C)
Graph 1. VCCUV+, VCCUV- vs TEMP
1600
1400
1200
1000
800
600
400
200
0
0
0.5 1 1.5 2 2.5
DeadTim e(µS )
Graph 2. CT vs Dead Time
3
9
8
CT+
7
6
CT-
5
4
3
2
1
0
-25 0 25 50 75 100 125
Temperature (°C)
Graph 3: CT+, CT- vs TEMP
www.irf.com
1000000
100000
10000
1000
5
25 45 65
RT(KΩ)
85
Graph 4: Frequency vs RT
11
11 Page |
Páginas | Total 29 Páginas | |
PDF Descargar | [ Datasheet IR2166.PDF ] |
Número de pieza | Descripción | Fabricantes |
IR2161 | Halogen Converter Control IC | International Rectifier |
IR2161PbF | HALOGEN CONVERTOR CONTROL IC | International Rectifier |
IR2161S | Halogen Converter Control IC | International Rectifier |
IR2161SPbF | HALOGEN CONVERTOR CONTROL IC | International Rectifier |
Número de pieza | Descripción | Fabricantes |
SLA6805M | High Voltage 3 phase Motor Driver IC. |
Sanken |
SDC1742 | 12- and 14-Bit Hybrid Synchro / Resolver-to-Digital Converters. |
Analog Devices |
DataSheet.es es una pagina web que funciona como un repositorio de manuales o hoja de datos de muchos de los productos más populares, |
DataSheet.es | 2020 | Privacy Policy | Contacto | Buscar |